Ducati Diavel
Free Service and Repair manuals

Ducati Diavel Service Manual: Component assembling position

Component assembling position


The throttle valve position sensor is integrated in the throttle valve actuator motor.

Component assembling position


Location of electric connection for throttle valve actuator motor - tps (throttle valve position sensor).

Connection wiring diagram

Connection wiring diagram


Ccm engine control connection, s throttle valve position sensor. Main potentiometer p: 3 signal, orange/blue - o/b, secondary potentiometer s: 1 signal, orange/green - o/g, 4 common ground, black/yellow bk/y, 2 common power (5v), brown/yellow - bn/y.

In the event of fault

In the event of a throttle valve position sensor fault, the ecu disables the ride-by-wire system and the engine will not start, remains running at idle or stops.

Fault codes generated and possible correlated faults

Fault codes generated by the engine control unit and displayed by the dds (throttle position sensor diagnosis):

Note

Check integrity of electric circuit - short-circuit to vdc = with dashboard on, using a voltmeter, a voltage is measured between the wire tested and ground.

Check integrity of electric circuit - short-circuit to ground = with the battery cables disconnected, using an ohmmeter, continuity is detected between the wire tested and ground.

Check integrity of electric circuit - open circuit = with the battery cables disconnected, using an ohmmeter, no continuity is detected between the two ends of the wire tested.

The dashboard service display shows the error "throttle position" and the eobd warning light activates.

Possible correlated faults: the engine does not start, cuts out or remains running at idle speed and will not accelerate.

Check:

The throttle valve actuator motor may be actuated into three preset positions (0%, 50%, 100%) using the dds.

The dds may be used to read the throttle valve position value.

If none of the tests described above identify the problem and the throttle valve position sensor is in proper working order, contact ducati.

Component replacement methods

The throttle valve position sensor is integrated into the throttle valve actuator motor and cannot be replaced as an individual component. In case it brakes down it will be necessary to fit a new throttle body (refer to this section operating principle and characteristics of the ride-by-wire system). After replacement of the throttle body, reset the self-adaptive parameters relative to carburation with the dds. Adjust the cables connecting the throttle grip to the throttle grip position sensor.

Throttle valve position sensor
Introduction The throttle valve position sensor (tps) of the diavel is mounted on the throttle body. The sensor is integrated into the throttle valve actuator motor, which turns the spindle ...

Air temperature sensor
Introduction The engine control system on the diavel uses a sensor that measures air temperature. This sensor has a resistance of ntc type (negative temperature coefficient), that reduces its own ...

Other materials:

Electrical power for lighting and signalling devices
The front and rear running lights consist of led units with light conduits. As a result, the light source is not visible as the light is diffused through the surface of the light conduit. These two images illustrate the front and rear running lights with light conduits. The figure ...

Injection and ignition
Introduction Ignition is via a single stick coil per cylinder installed in the spark plug well. Each thermal unit is supplied by a single injector, placed under the throttle valve. The amount of fuel injected and the ignition advances are determined by the control unit specifically for each c ...

Evaporative emissions canister system (usa versions only)
Usa models are equipped with an additional system with an evaporative emissions canister that prevents fuel fumes from being discharged into the atmosphere. The breather hose (4) is connected to the canister filter (1); when the fuel has been filtered, it is returned through the hose (2) to t ...

2022 | www.dudiavel.com |